Jump to content

FloRider

Members
  • Content count

    17
  • Joined

  • Last visited

Community Reputation

2 Neutral

About FloRider

  • Rank
    TT Newbie

Profile Information

  • Location
    Oman
  1. FloRider

    Easy task gone wrong

    Could try pushing in a straightened fishing hook, the barbs might do the trick. Or see if you can pressure up the hole behind the cotton with compressed air.
  2. FloRider

    05 525mxc dies when hot!?

    Just came accross this post again, and wanted to add that I had measured the resistance of the components before replacing. Hard to believe, but the ignition coil primary circuit, spark plug cap and stator were outside the ktm specs (@ 25'C) but the ignition coil was NOT! Must have shorted out only when getting hot. So the only part within the specs was the culprit. That is also why I replaced it last.
  3. FloRider

    05 525mxc dies when hot!?

    Just to inform, the stator did not fix my problem but a new ignition signal pickup spool did!
  4. FloRider

    530 EXC cutting out when hot

    Found it!! The ignition signal pickup spool was deep fried! Thanks for your thinking along gents!
  5. FloRider

    Suzuki GSX-R750 1998

    Good on the road, brilliant on the track!
  6. FloRider

    Suzuki GSX-R750 (1998)

    0 comments

    Good on the road, brilliant on the track!
  7. FloRider

    Ducati Monster S4R 2006

    Not easy to ride fast but a lot of good old clean fun!
  8. FloRider

    Ducati Monster S4R (2006)

    0 comments

    Not easy to ride fast but a lot of good old clean fun!
  9. FloRider

    Honda CRF450X (2007)

    0 comments

    Reliable hard working bike, fun to ride although less explosive than the KTM 530.
  10. FloRider

    Honda CRF450X 2007

    Reliable hard working bike, fun to ride although less explosive than the KTM 530.
  11. FloRider

    KTM 530 EXC-R (2009)

    0 comments

    A bitch on reliability but a hell of a ride
  12. FloRider

    KTM 530 EXC-R 2009

    A bitch on reliability but a hell of a ride
  13. FloRider

    530 EXC cutting out when hot

    Just test ridden the bike. Issue is not resolved just yet... So in my view that leaves only signal coil or cdi. Before she stops there often is a misfire. If i then take it very slowly she will keep running. If i keep the power on she'll stop firing completely within some seconds. While rolling I can twist the throttle but no effect at all. If it were fuel then she'd fire on the injected fuel from the accelerator pump I would think?
  14. FloRider

    530 EXC cutting out when hot

    OK. I disconnected kill switch, checked all relevant connectors again, checked & cleaned grounds, put alu tape on carb bowl and hose. Also checked the wiring plan and found that a) the kill switch is nortmally open, so not likely to fault for the ignition circuit, the voltage regulator is in parallel to the battery so if either one fails the bike should keep running (that is until the battery is flat) Will go for a test run tonight, keep you posted...
  15. FloRider

    530 EXC cutting out when hot

    Just checked, 500 EXC CDI, voltage regulator and pick up spool are different.
×